Body - Noise From the Convertible Top Compartment Cover
61 Noises from the convertible top compartment cover
361
61 11 11
2023305/3
February 3, 2011.
Supersedes Technical Service Bulletin Group 61 number 10 - 05 dated May 18, 2010 for reasons listed below.
AFFECTED VEHICLES
CONDITION
362
Squeaking or creaking noises from the rear of the vehicle interior. Specifically, the noises come from the area where the convertible top compartment
cover comes in contact with the rear seat backrest and seat belt guidance element (Figures 1 and 2).
TECHNICAL BACKGROUND
When driving on uneven roads, squeaking or creaking noises arise from these points of contact. This condition is exhibited with the convertible top
either open or closed.
PRODUCTION SOLUTION
Improved buffers to isolate points of contact.
SERVICE
363
1. Install stop buffers (part number 893 837 739 A) on the trim of the left and right rollover bar. Attach the self-adhesive stop buffers as shown in
Figure 3.
364
2. After attaching the stop buffers, check the position of the adjustable center buffer located on the convertible top compartment cover. The total
extended length of the center buffer from base to tip is 21 mm (Figure 5).
3. Check whether this center buffer makes contact with the beam below it when the cover is closed (Figure 6).
^ Fold down the two rear seat backrests if necessary to make the adjustment. A slight readjustment may be necessary to establish contact.
^ Ensure the pressure is not excessive.
Note:
^ The adjustable center buffer is only for the support. Excessive pressure from this buffer will distort the cover.
WARRANTY
365
REQUIRED PARTS AND TOOLS
ADDITIONAL INFORMATION
All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service
manuals for the latest information.
